Mr. Heater 3500DF Especificaciones

INSTALLATION ANDOPERATION MANUALVantage (VTG)Condensing Hydronic BoilersStandard, Dual Fuel, and Low Emissions Models2,000,000 - 6,000,000 BTU/HRSeria

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-4TABLE 1  BOILER DIMENSIONS AND OPERATING REQUIREMENTS MODEL

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 2 VTG-IOM-2012-1001 INSTALLATION2-5FIGURE 1  VIEWS OF VANTAGE HYDRONI

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-6 » Be supported by means other than the safety valve itself. » Be piped to avo

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-7SECTION 2 VTG-IOM-2012-1001 INSTALLATION ! WARNINGAll information in this m

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-8FIGURE 2  SAFETY VALVE LOCATIONFIGURE 3  SAMPLE PIPING LAYOUTNote: Sample pi

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-9SECTION 2 VTG-IOM-2012-1001 INSTALLATION 4 CAUTIONCare needs to be taken to

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-10 ¡ Eliminate System Air NOTE: ´ There are no built-in boiler air eliminating

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-11SECTION 2 VTG-IOM-2012-1001 INSTALLATION ! WARNINGAll information in this

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-12FIGURE 5  CONDENSATE DRAIN PIPING FOR VANTAGE BOILERSFigure 5 Notes: § Heade

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 2 VTG-IOM-2012-1001 INSTALLATION2-138. Attach a ¼” water supply to th

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-14Install Oil Piping ¡ Oil Piping (For Dual Fuel Boilers with the Riello Burner

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-15SECTION 2 VTG-IOM-2012-1001 INSTALLATION ! WARNINGAll information in this

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-16 Figure 9 NotesCharacteristic Connection1Suction 3/8” NPT (Piped in the

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 2 VTG-IOM-2012-1001 INSTALLATION2-17AB735274665VP+H-H3 1516Supplied wi

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-18TABLE 4  GENERAL VENTING REQUIREMENTSVantage Model NumberMaximum Negative Dr

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-19SECTION 2 VTG-IOM-2012-1001 INSTALLATION11. Particulate matter or chemica

© The Fulton Companies 20122-20INSTALLATION VTG-IOM-2012-1001 SECTION 2Exhaust VentingThe Vantage is equipped with a vent connection (Figure 4) at t

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-21SECTION 2 VTG-IOM-2012-1001 INSTALLATION ¡ Common Venting Layouts for Vant

© The Fulton Companies 20122-22INSTALLATION VTG-IOM-2012-1001 SECTION 2 NOTE: ´ Consider all possible draft conditions (based on the modulation and

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 2 VTG-IOM-2012-1001 INSTALLATION2-231/4" TAPPING FOR WATER100 PSI

Questions? Call (315) 298-5121, or visit us online at www.fulton.comVTG-IOM-2012-1001 TABLE OF CONTENTS0-1Introduction 1-1Overview ...

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-24FIGURE 13  WALL PENETRATION DETAILSEXHAUSTVANTAGE HYDRONICBOILERRISE TO RUN:

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-25SECTION 2 VTG-IOM-2012-1001 INSTALLATION5. Install two pipe retaining cla

© The Fulton Companies 20122-26INSTALLATION VTG-IOM-2012-1001 SECTION 2downwind from air supply inlet to prevent exhaust recirculation. 5. Under ce

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-27SECTION 2 VTG-IOM-2012-1001 INSTALLATION5. Test for spillage at the draft

© The Fulton Companies 2012INSTALLATION VTG-IOM-2012-1001 SECTION 22-28Assembly of Fulton Multi-Skid SystemsAdhere to the following for multi-skid e

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-1OPERATION INTRODUCTION 1 INSTALLATION 2 OPERATION 3 MAINTENANCE 4 WARRAN

© The Fulton Companies 20123-2OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGAll information in this manual is for reference and guidance purposes,

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-3SECTION 3 VTG-IOM-2012-1001 OPERATION ! WARNINGCrystalline silica may be pr

© The Fulton Companies 20123-4OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGNon-Fulton product information is for reference purposes only. No Fulto

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-5SECTION 3 VTG-IOM-2012-1001 OPERATION ! WARNINGNon-Fulton product informati

© The Fulton Companies 2012TABLE OF CONTENTS VTG-IOM-2012-10010-2DUAL FUEL  RIELLO BURNER ...

© The Fulton Companies 20123-6OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGNon-Fulton product information is for reference purposes only. No Fulto

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-7SECTION 3 VTG-IOM-2012-1001 OPERATION ! WARNINGAll information in this manu

© The Fulton Companies 20123-8OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNING All information in this manual is for reference and guidance purposes,

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-9SECTION 3 VTG-IOM-2012-1001 OPERATION ! WARNINGAll information in this manu

© The Fulton Companies 20123-10OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGAll information in this manual is for reference and guidance purposes,

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-11SECTION 3 VTG-IOM-2012-1001 OPERATION ! WARNINGAll information in this man

© The Fulton Companies 20123-12OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGAll information in this manual is for reference and guidance purposes,

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-13SECTION 3 VTG-IOM-2012-1001 OPERATION 4 WARNINGAll information in this man

© The Fulton Companies 20123-14OPERATION VTG-IOM-2012-1001 SECTION 3 4 WARNINGAll information in this manual is for reference and guidance purposes,

Questions? Call (315) 298-5121, or visit us online at www.fulton.com3-15SECTION 3 VTG-IOM-2012-1001 OPERATION 4 WARNINGNon-Fulton product informat

Questions? Call (315) 298-5121, or visit us online at www.fulton.com1-1INTRODUCTION INTRODUCTION 1 INSTALLATION 2 OPERATION 3 MAINTENANCE 4 WAR

© The Fulton Companies 20123-16OPERATION VTG-IOM-2012-1001 SECTION 3 ! WARNINGDo not operate, or allow others to operate, service or repair this equ

Questions? Call (315) 298-5121, or visit us online at www.fulton.com4-1MAINTENANCE INTRODUCTION 1 INSTALLATION 2 OPERATION 3 MAINTENANCE 4 WARR

© The Fulton Companies 20124-2MAINTENANCE VTG-IOM-2012-1001 SECTION 4 ! WARNINGAll information in this manual is for reference and guidance purposes

Questions? Call (315) 298-5121, or visit us online at www.fulton.com4-3SECTION 4 VTG-IOM-2012-1001 MAINTENANCE ! WARNINGAll information in this ma

© The Fulton Companies 20124-4MAINTENANCE VTG-IOM-2012-1001 SECTION 4 4 CAUTIONAll information in this manual is for reference and guidance purposes

Questions? Call (315) 298-5121, or visit us online at www.fulton.com4-5SECTION 4 VTG-IOM-2012-1001 MAINTENANCE 4 CAUTIONAll information in this ma

© The Fulton Companies 20124-6MAINTENANCE VTG-IOM-2012-1001 SECTION 4 ! WARNINGAll information in this manual is for reference and guidance purposes

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 4 VTG-IOM-2012-1001 MAINTENANCE4-7termination point. Also note the loc

© The Fulton Companies 2012MAINTENANCE VTG-IOM-2012-1001 SECTION 44-8TROUBLESHOOTINGPROBLEM CAUSE CHECKControl does not illuminate Power supply Chec

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 4 VTG-IOM-2012-1001 MAINTENANCE4-9PROBLEM CAUSE CHECKMain  ame fails

© The Fulton Companies 2012INTRODUCTION VTG-IOM-2012-1001 SECTION 31-2OverviewPrior to shipment, the following inspections and tests are made to ens

© The Fulton Companies 2012MAINTENANCE VTG-IOM-2012-1001 SECTION 44-10PROBLEM CAUSE CHECKLow Air Flow Supply indi-cated on low air switch Low Air is

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 4 VTG-IOM-2012-1001 MAINTENANCE4-11

© The Fulton Companies 2012MAINTENANCE VTG-IOM-2012-1001 SECTION 44-12

Questions? Call (315) 298-5121, or visit us online at www.fulton.com5-1WARRANTY & PARTS INTRODUCTION 1 INSTALLATION 2 OPERATION 3 MAINTENANC

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-2

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-3Standard Warranty for Fulto

PAGE INTENTIONALLY LEFT BLANK

Questions? Call (315) 298-5121, or visit us online at www.fulton.com5-5SECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS ! WARNINGUse of non-factor

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-6 } VANTAGE STANDARD - MAXON BURNER } PARTNUMBER } MODEL } DESCRIPTION

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-7 } VANTAGE STANDARD - MAXON

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-1INSTALLATION INTRODUCTION 1 INSTALLATION 2 OPERATION 3 MAINTENANCE 4 WAR

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-8 } VANTAGE STANDARD - MAXON BURNER } PARTNUMBER } MODEL } DESCRIPTION

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-9 } VANTAGE STANDARD - MAXON

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-10 } VANTAGE DUAL FUEL - RIELLO BURNER } PART NUMBER } MODEL } DESCRIPT

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-11 } VANTAGE DUAL FUEL - RIE

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-12 } VANTAGE DUAL FUEL - RIELLO BURNER } PART NUMBER } MODEL } DESCRIPT

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-13 } VANTAGE DUAL FUEL - RIE

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-14 } VANTAGE LOW EMISSIONS - BEKAERT BURNER } PART NUMBER } MODEL } DES

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-15 } VANTAGE LOW EMISSIONS -

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-16 } VANTAGE LOW EMISSIONS - BEKAERT BURNER } PART NUMBER } MODEL } DES

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-17 } VANTAGE LOW EMISSIONS -

© The Fulton Companies 20122-2INSTALLATION VTG-IOM-2012-1001 SECTION 2 ! WARNINGAll information in this manual is for reference and guidance purpose

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-18 } ANNUAL MAINTENANCE KITS } 2-20-000023 } 3” WATER LEVEL PROBE } 4-

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-19 } ANNUAL MAINTENANCE KITS

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-20 } ANNUAL MAINTENANCE KITS } 2-12-000544 } PRIMARY PV MILL BOARD GAS

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-21 } SPARE PARTS KITS } 2-40

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-22 } SPARE PARTS KITS } 2-40-000878 } 3RT1015-1AK6 MOTOR CONTACTOR 7 A

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-23 } SPARE PARTS KITS } 2-40

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-24 } SPARE PARTS KITS } 2-40-000819 } RTD 3/16” OD WITH 4” INSERTION

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-25 } PAST DESIGNS } PART NO

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-26 } PAST DESIGNS } PART NO } DESCRIPTION } VTG-2000 } VTG-3000 } VTG-4

Questions? Call (315) 298-5121, or visit us online at www.fulton.comSECTION 5 VTG-IOM-2012-1001 WARRANTY & PARTS5-27

Questions? Call (315) 298-5121, or visit us online at www.fulton.com2-3SECTION 2 VTG-IOM-2012-1001 INSTALLATION ! WARNINGAll information in this m

© The Fulton Companies 2012WARRANTY & PARTS VTG-IOM-2012-1001 SECTION 55-28

The Fulton Companies972 Centerville Road, Pulaski, NY 13142Call: (315) 298-5121 • Fax: (315) 298-6390www.fulton.com VTG-IOM-2012-1001The heat trans